Electrical system: Wiring10/30/201818V764000
Grand Design RV, LLC is recalling certain 2018-2019 Reflection fifth wheel trailers, models 28BH and 29RS. The circuit for the power converter does not have over-current protection.
Consequence
An electrical short circuit in the unprotected circuit can increase the risk of a fire.
Remedy
Grand Design RV will notify owners, and dealers will inspect the trailers to determine if the 50-amp mini breaker at the bus bar is installed correctly and that the circuit is wired correctly, correcting it as necessary, free of charge. The recall began November 19, 2018. Owners may contact Grand Design RV customer service at 1-574-825-9679. Grand Design RV's number for this recall is 910017.
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Electrical system10/16/201818V729000
Grand Design RV, LLC (Grand Design) is recalling certain 2019 Grand Design Reflection travel trailers, models 285BHTS, 287RLTS and 297RSTS. The wires to the 50 amp mini-breaker may be installed incorrectly, leaving the circuit unprotected.
Consequence
If the unprotected circuit overheats or experiences a short, it can increase the risk of a fire.
Remedy
Grand Design will notify owners, and dealers will inspect the 50 amp mini-breaker to make sure that it is wired correctly, re-wiring it as necessary, free of charge. The recall began November 12, 2018. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910016.
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Suspension: Rear: Axle: Non-powered axle assembly09/24/201818V658000
Grand Design RV, LLC (Grand Design) is recalling certain 2019 Grand Design Reflection, Imagine and Transcend travel trailers. These axles may be missing inner bearings on the hubs, which can cause the bearing to burnout or cause the hub to overheat.
Consequence
If the bearings prematurely wear, it can cause the hub to overheat and smoke, increasing the risk of a fire.
Remedy
Grand Design will notify owners, and dealers will replace the defective hubs with new hubs or replace the axles, free of charge. The recall began October 22, 2018. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910015.
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Equipment: Electrical09/14/201818V637000
Grand Design RV (Grand Design) is recalling certain 2019 Grand Design Reflection travel trailers, model 295RL. The outside 110V outlet was not correctly wired to a ground-fault (GFI) protected circuit.
Consequence
In the event of an electrical issue with an appliance or component that is plugged into the outside electrical outlet, an electrical shock may result, increasing the risk of injury.
Remedy
Grand Design will notify owners, and dealers will install a new correctly wired ground fault receptacle, free of charge. The recall began October 8, 2018. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 900014.
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Equipment: Appliance: Refrigerator01/28/202222V038000
Grand Design RV, LLC (Grand Design) is recalling certain 2013-2021 Momentum, Solitude, and Reflection recreational vehicles. A 110-volt wire in the refrigerator cabinet may be improperly secured, which could result in the wire contacting the refrigerator cooling unit, causing an electrical arc.
Consequence
An electrical arc increases the risk of a fire.
Remedy
Dealers will inspect and replace any damaged wiring, and properly secure the wires, free of charge. Owner notification letters were mailed on February 21, 2022. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910026.
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.